Pfaff-Silberblau EGU 15E Lithium-Ion Battery Pack 20 Ah

Spare Battery for EGU 15E Electric Pallet Truck | 24V Lithium-Ion | 3,000 Cycles

This listing is for the battery pack only — a genuine Pfaff-Silberblau replacement or spare battery pack for the EGU 15E electric pallet truck. The 20 Ah Lithium-Ion pack is the standard battery for single-shift operation and is fully interchangeable across the EGU 15E fleet: order spares to enable battery-swap working for multi-shift operation, or as direct replacements when an existing pack reaches end-of-life. Supplied with the same charging stand connectors as the original truck installation, with 3,000 charge cycles to 80% of new capacity.

Key Features

• Genuine Pfaff specification — the only battery pack approved for use in the EGU 15E. Third-party Lithium-Ion packs are not supported and will void truck warranty.
• Swappable in under a minute — the pack format is designed for quick interchange. Standard procedure: power off truck, release latch, lift pack out, insert charged pack, latch, power on.
• Opportunity charging supported — no battery memory effect. A 30-minute top-up between shifts restores significant capacity without damaging the cells.
• 3,000-cycle life — typical commercial service life of 5 to 8 years before capacity drops below 80% of new.
• Integrated battery management — the pack contains its own battery management system (BMS) that protects against over-charge, over-discharge, over-temperature, and short circuit. The BMS communicates with the truck controller via CAN-Bus to report state-of-charge.

Technical Specifications

Safety Information

• Charge only on the Pfaff supplied charging stand. Do not use any third-party charger.
• Do not drop, impact, or pierce the battery casing.
• A damaged battery (swelling, leakage, abnormal heating) must be removed from service immediately and stored in a fire-safe location pending disposal.
• Do not store batteries in direct sunlight or near sources of heat.
• Dispose of end-of-life batteries through a registered battery recycler. Lithium-Ion batteries are classified as hazardous waste under UK regulations.

Downloads

• Pfaff EGU 15E Battery Datasheet (EN, PDF)

Frequently Asked Questions